Various

“ In the residences of several of our partners no fuel other than this gas is now used, and everybody who has applied it to domestic purposes is delighted with the change from the smoky and dirty bituminous coal. Some, indeed, go so far as to say that if the gas were three times as costly as the old fuel, they could not be induced to go back to the latter. It is therefore quite within the region of probability that the city, now so black that even Sheffield must be considered clean in comparison, may be so revolutionized as to be the cleanest manufacturing center in the world. ”

“ When we consider that we in London have only 30 gallons a head daily, and that many other towns have less, we get some idea of the profusion with which water was supplied to ancient Rome. But the remains of Roman aqueducts are not only to be found near Rome. Almost every Roman city, whether in Italy or in the south of France, or along the north coast of Africa, can show the remains of its aqueduct, and almost the only things that are to be seen on the site of Carthage are the remains of the Roman water tanks and the ruins of the aqueduct which supplied them. ”

“ At the present day, an electrical torpedo may be described as consisting of a strong, water-tight vessel of iron or steel, which contains a large amount of some explosive, usually gun-cotton, and a device for detonating this explosive by electricity. The old mechanical mine used in our civil war did not know a friendly ship from a hostile one, and would sink either with absolute impartiality. But the electrical submarine mine, being exploded only when a current of electricity is sent through it from ship or shore, makes no such mistake, and becomes harmless when detached from the battery. ”

“ It is easy to see that if a curved wire is pulled straight, there must occur a distention of the particles on the inside of the curve and a compression of those on the outside. The inside is in fact strained past its elastic limit before any stress comes upon the outside. Hence, after the wire has been pulled straight, the elastic limit of only a portion of it can be taken into the account in calculating the load that can safely be put upon it. In the case of curved steel wire pulled straight, its ultimate strength was found to be only about 90 per cent. ”

“ THE HELICOIDAL OR WIRE STONE SAW.
The sides of solid bodies, whatever be the degree of hardness, and however fine the texture, possess surfaces formed of a succession of projections and depressions. When two bodies are in contact, these projections and indentations fit into one another, and the adherence that results is proportional to the degree of roughness of the surfaces. If, by a more or less energetic mechanical action, we move one of the bodies with respect to the other, we shall produce, according as the action overcomes cohesion, more or less disintegration of the bodies. ”

“ Being so free from all deleterious elements, notably sulphur, it makes better iron, steel, and glass than coal fuel. It makes steam more regularly, as there is no opening of doors, and no blank spaces are left on the grate bars to let cold air in, and, when properly arranged, regulates the steam pressure, leaving the man in charge nothing to do but to look after the water, and even that could be accomplished if one cared to trust to such a volatile water-tender. ”

“ When a current of electricity goes through a wire, it heats it; and if the current be made strong enough, and a white hot wire thus comes in contact with powder or fulminate of mercury in a torpedo, an explosion will result. But it is important to know exactly when to explode the torpedo, especially during the night or in a fog; and hence torpedoes are often made automatic by what is called a circuit closer. This is a device which automatically bridges over the distance between two points which were separated, thus allowing the current to pass between them. ”

“ The officer discharges the guns from a fighting tower, whither the wires lead, and the men can at once lie down out of the enemy's machine guns, as soon as their own guns are ready for discharge. The electric motor will certainly be used very generally for handling ordnance on board ships not very heavily plated with armor, since a small wire is a much more convenient mode of conveying energy to a motor of any kind, and is much less liable to injury, than a comparatively large pipe for conveying steam, compressed air, or water under pressure. ”

“ In submarine torpedoes it is usual to employ a small weight, which, when the torpedo is struck, is thrown by the force of the blow across two contact points, one of which points is in connection with the fuse and the other in connection with the battery, so that the current immediately runs over the bridge thus offered, and through the fuse. In practice, these two contact points are connected by a wire, even when the torpedo is not in the state of being struck; but the wire is of such great resistance that the current is too weak to heat the wire in the fuse. ”

“ Bearing in mind that it is never wise to prophesy unless you know, I hesitate to speak of the future; but considering the experience we have had in regard to the productiveness of the oil territory, which is now yielding 70,000 barrels of petroleum per day, and which has continued to increase year after year for twenty years, I see no reason to doubt the opinion of experts that the territory which has already been proved to yield gas will suffice for at least the present generation in and about Pittsburg. ”

“ In the work around Pittsburg beyond the city limits, the amount of coal superseded by gas is about equal to that displaced in the city. The estimated number of men whose labor will be dispensed with in Pittsburg when gas is generally used is 5,000. It is only a question of a few months when all the manufacturing carried on in the district will be operated with the new fuel. As will be seen from the analyses appended to this paper, it is a much purer fuel than coal; and this is a quality which has proved of great advantage in the manufacture of steel, glass, and several other products. ”

“ In the iron mills the puddlers have whitewashed the coal bunkers belonging to their furnaces. I need not here say how much pleasure it will afford me to arrange that any fellow members of the Institute who may visit the republic are afforded an opportunity to see for themselves this latest and most interesting development of the fuel question. Good Mother Earth supplies us with all the fuel we can use and more, and only asks us to lead it under our boilers and into our heating and puddling furnaces, and apply the match. ”

“ Safety hooks are often fitted to winding ropes, and although the damage to life and property is greatly reduced by the use of them, they do not protect a descending cage from injury in a case of overwinding; besides which, they are almost useless when a wild run takes place, an accident which, strange to say, has already occurred many times after engines and boilers have been laid off for repairs. Stop valves are left open, the reversing lever is not fixed in mid-gear, steam is got up in the boilers at a time when no one is in the engine house, and the engines run away. ”

“ The cost to-day does not exceed £1,500 per mile. As our coal was not costing us more than 3s. per ton of finished rails, the inducement was not in our opinion great enough to justify the expenditure of so much capital and taking the risk of failure of the supply. Two years ago men who had more knowledge of the oil-wells than ourselves had sufficient faith in the continuity of the gas supply to offer to furnish us with gas for a sum per year equal to that hitherto annually paid for coal until the amount expended by them on piping had been repaid, and afterward at half that sum. ”

“ In our Union Iron Mills we have attached to each puddling furnace a small regenerative appliance, by the aid of which we save a large percentage of fuel. The gas companies will no doubt soon require manufacturers to adopt some such appliance. At present, owing to the fact that there is a large surplus constantly going to waste, they allow the gas to be used to any extent desired. Contracts are now made to supply houses with gas for all purposes at a cost equal to that of the coal bill for the preceding year. ”

“ In the case of manufacturing establishments, the gas is led into the mills overhead, and, all the pipes being in the open air, no danger of explosion is incurred.
The following extract from the report of a committee, made to the American Society of Mechanical Engineers at a recent meeting, gives an idea of the value of the new fuel: "Natural gas, next to hydrogen, is the most powerful of the gaseous fuels, and, if properly applied, one of the most economical, as very nearly its theoretical heating power can be utilized in evaporating water. ”

“ It will be seen that the larger and better product of labor is a great factor in the profitableness of such enterprises, and that it arises from the improved character of the laborer, on the same principle that a farmer's stock pays him best when it is of good breed, is warmly housed, and well fed. ”

“ We frequently find otherwise good doors hung on wooden jambs by ordinary screws. Sliding doors are frequently hung on to woodwork, and all attachments are frequently so arranged that they would be in a very short time destroyed by fire, and cause the door to fall. In case of fire, a solid iron door offers no resistance to warping. In an iron lined door, on the contrary, the tendency of the sheet iron to warp is resisted by the interior wood, and when this burns into charcoal, it still resists all warping tendencies. ”

“ Recent experiments in England have shown that the Whitehead torpedo, over which control ceases after it is fired, is not so formidable a weapon when fired at a ship under way as many supposed, for the simple reason that it can be dodged. But an electrical torpedo, over which control is exercised while it is in motion through the water, cannot be dodged, provided it receives sufficient speed. For effective work against ships capable of steaming fifteen knots per hour, the torpedo should have a speed of twenty knots. ”

“ The telegraph and telephone are both coming largely into use in artillery experiments, for example, in tracking a vessel as she comes up a channel so that her exact position at each instant may be known, and in determining the spot of fall of a projectile. In getting the time of flight of projectiles electricity is of value; by breaking a wire in circuit with a chronograph, the precise instant of start to within a thousandth of a second being automatically registered. Velocimeters are a familiar application of electricity somewhat analogous. ”

“ The telephone is also used with success in warfare, and in fact sometimes assists the telegraph in cases where, by reason of the haste with which a line has been run, the current leaks off. A telephone may then be used to receive the message—and for a transmitter a simple buzzer or automatic circuit breaker, controlled by an ordinary key. In the case of vessels there is much difficulty in using the telegraph and the telephone, as the wire may be fouled and broken when the ship swings by a long chain. ”

“ So much has been claimed for natural gas as regards the superiority of its heating properties as compared with coal, that some analyses of this gas, together with calculations showing the comparison between its heating power and that of coal, may be of interest. These calculations are, of course, theoretical in both cases, and it must not be imagined that the total amount of heat, either in a ton of coal or 1,000 cubic feet of natural gas, can ever be fully utilized. ”

“ In submarine boats electricity will one day be very useful. Submarine diving will play a part in future wars, and the diver's lamp will be electrical.
Progress has been made also in constructing "electrical guns," in which the cartridge contains a fuse which is ignited by pressing an electric button on the gun. A better aim can be had with it, when perfected, than with one fired by a trigger. At present, according to Lieut. Fiske, this invention has not reached the practical stage, and the necessity for a battery to fire a cartridge is decidedly an objection. ”

“ In these days of depression in manufacturing, the world over, it is specially cheering to be able to dwell upon something of a pleasant character. Listen, therefore, while I tell you about the natural gas fuel which we have recently discovered in the Pittsburg district. That Pittsburg should have been still further favored in the matter of fuel seems rather unfair, for she has long been noted for the cheapest fuel in the world. The actual cost of coal, to such as mine their own, has been between 4s. and 5s. per ton ”

“ Pullman, who founded the enterprise on Calumet Lake, has uttered sentiments like these, and has proved that in this instance it does pay to make his workmen's families comfortable, and secure from sickness and temptation. As a financial operation Pullman is profitable. There are now 1,700 dwellings, either separate or in apartment houses, in this town, where five years ago the prairie stretched on every side unbroken. Every tenement is connected with common sewerage, water, and gas systems, in which the most scientific principles and expert skill have been applied. ”

“ To throw a good light upon the target the same inventor has devised a small electric lamp and projector, which is placed on the barrel near the muzzle by rubber bands, the battery being held at the belt of the marksman, with such connections that the act of pressing the butt of the musket against the shoulder completes the circuit, and causes the bright cylinder of light to fall on the target, thus enabling him to get as good a shot as in the day time. ”

“ The Romans were not so foolish as to construct underground siphons, many miles long, for the supply of Rome; but where it was necessary to construct them for the purpose of crossing deep valleys, they did so. The same emperor Claudius who built the aqueduct at Rome known by his name built the aqueduct of Mont Pila, at Lyons, and it is quite clear, therefore, that his engineers were practically well acquainted with the principles of hydraulics. ”

“ At Pullman, in addition to the shops and dwellings, there are trees and turf-bordered malls and squares, a church, a theater, a free library with reading rooms, a public hall, a market house, provided at the expense of the company. Liquor can only be sold at the hotel to its guests, and then under restrictions. There is a system of public schools under a board of education, which is about the only civic organization, strictly speaking, in the community. One man suffices for police duty, and he made but fifteen arrests in the last two years. ”

“ The fuel to run these drills is conveyed by small pipes from adjoining wells. An 8-inch hole having been bored to a depth of about 500 feet, a 5-5/8 inch wrought-iron pipe is put down to shut off the water. The hole is then continued 6 inches in diameter until gas is struck, when a 4-inch pipe is put down. From forty to sixty days are consumed in sinking the well and striking gas. The largest well known is estimated to yield about 30,000,000 cubic feet of gas in twenty-four hours, but half of this may be considered as the product of a good well. ”

“ Irrespective of the manipulation of the hydrogen jet, it is rather difficult without long practice to hold the end of the fine wire precisely over the aperture and to keep it in position. It occurred to me that, if the gold in a finely divided condition could be placed in very intimate contact with the platinum, judging from the fusibility of gold-platinum alloys, union could be effected at a lower temperature over the ordinary gas blowpipe. ”

“ Many of the mills have as yet no appliances for using the gas, and much of it is still wasted. It is estimated that the iron and steel mills of the city proper require fuel equal to 166,000 bushels of coal per day; and though it is only two years since gas was first used in Pittsburg, it has already displaced about 40,000 bushels of coal per day in these mills. Sixty odd glass works, which required about 20,000 bushels of coal per day, mostly now use the natural gas. ”