Diesel fuel

“ This brings about the necessity for injecting the fuel in a well-atomized condition at the time that combustion is desired and the quantities of fuel injected at this time control the amount of heat generated; that is, an infinitesimally small quantity of fuel will be burned just as efficiently in the Diesel engine as a full charge of fuel, whereas in the gasoline engine the mixture ratio must be kept reasonably constant and, if the supply of fuel is to be cut down for throttling purposes, the supply of air must be correspondingly reduced. ”

“ Diesel Oil Engine. The Diesel engine marks the greatest progress in the internal combustion field made in the last few years. It marks a distinct advance in both thermal efficiency, and in the character of the fuel that it has made a commercial possibility. By the use of cheap fuel heretofore unavailable for any type of prime mover, such as the asphaltum residual oils, coal tar, etc., it has lowered the cost of power production to a point where it is unapproached by any type of heat engine. ”

“ Then too, whatever air may escape contains no fuel, and consequently efficient scavenging may be obtained without waste.
At the high pressure at which the fuel is injected into the cylinder of the Diesel engine, practically any grade of gasoline, naphtha, kerosene, crude oil, or other form of petroleum can be vaporized. The compressed air employed in the compression and injection of the fuel is also used for starting the motor, for this is not a type that is amenable to hand cranking. ”

“ A wide range of fuels may be used in an internal-combustion engine. They may be either gaseous, liquid, or even solid. In stationary engines hydrogen, coal gas, natural gas, blast-furnace gas, and [156] producer gas are employed to advantage. Volatile fuels, such as alcohol, bensol, gasoline, and kerosene, are turned into a mist or vapor and then burned as a gas. In engines of the Diesel type any liquid fuel ranging down to thick crude oils may be employed, and in one type of engine, which, however, has not proved commercially practicable, coal dust is burned in the cylinder. ”

“ Exposition, 1904, three Diesel engines, using oil costing three cents per gallon, delivered for seven months, during eleven hours each day, at half-load, an average of 250 kilowatts at an expense for fuel of but three tenths of one cent per kilowatt hour on the switchboard, including all generator and line losses. Engineers of the first rank are convinced that the Diesel principle may be successfully embodied in gas engines. That done, with a success approaching the effectiveness of Diesel’s oil motor, we may expect steam engines and turbines to be largely dismissed from service. ”

“ In tropical theaters, a thickened blend of 50 percent gasoline and 50 percent light fuel oil has been reported to give favorable results. Storage qualities are not known, however. Another mixture which has been well recommended in field reports is 15 gallons of gasoline to 5 gallons of diesel fuel oil. Issue gasoline may be used, but locally procured gasolines which contain alcohol are not suitable.
b. Proportion of thickener to fuel. Less thickener is recommended than formerly. A low ratio of thickener gives a thickened fuel with many of the characteristics of liquid fuel. ”

“ As the semi-Diesel type engine will operate successfully on the lowest grades of crude oils, with an efficiency that compares favorably with the true Diesel type, the operating expenses are very much lower than with the gas or gasoline engine. With the same fuels, the semi-Diesel will show greater net saving than the Diesel with a low load factor, as the fuel saving is not eaten up by the high first cost, and overhead charges of the true Diesel. ”

“ Residual oil which was hardly fluid at ordinary temperatures has been successfully used in the Diesel and semi-Diesel types of engines, by preheating it before admission to the inlet valves. The enormously increased demand for gasoline has resulted in a great increase of the formerly useless residual oil so that it is possible that the demand for gasoline will make the production of the residual great enough so that it can be seriously considered as a fuel. ”

“ The very best of our engineering talent have been so successfully concerned with this problem that fuel oil is now used in nearly every steam plant on land and sea, for both stationary and locomotive use. Petroleum-enriched water gas is much superior in cost and quality to the illuminant it is displacing, and now requires considerable oil. Smelting with oil will soon be an accomplished fact in spite of many difficulties, and oil engines such as the Diesel also utilize the crude. ”

“ In General— Each retail diesel fuel pump shall be labeled in a manner that informs consumers of the percent of biomass-based diesel or biodiesel that is contained in the biomass-based diesel blend or biodiesel blend that is offered for sale, as determined by the Federal Trade Commission. ”

“ In the Diesel motor, on the other hand, the ignition continues as long as fuel is admitted, and thus this engine is of the internal combustion type in the strictest sense of the word. It is, after all, the expansion of the gases due to the heat of combustion that produces the power in a gasoline engine, and if the fuel can be so admitted that it can burn during the greater part of the stroke, a high efficiency will be obtained. ”

“ How the Diesel Engine Works.—The Diesel engine works on the same general principle as the gasoline engine—that is, by the explosion of a fuel mixture in the cylinders—but it is different from the gasoline engine in the way in which the fuel is admitted into the cylinder and fired. ”

“ While gas can yield the full fuel value of coal in a more efficient form than solid fuel, as well as all the commodity values, if it is converted into power through the steam engine, at least one-half of its energy value is lost. To conserve its full value, gas must be burned in the internal-combustion engine, the most familiar type of which is the one we know under the hood [Pg 99] of the automobile and the most efficient type is the Diesel engine which has made the by-product system industrially practical. ”

“ Due to the greater simplicity, it was more practical to build a large diesel than a large gasoline engine. Large airplanes would therefore need fewer engines if diesel powered. Smaller fuel tanks could be used because of the greater fuel economy of the diesel, and also because of the high specific gravity of fuel oil as compared to gasoline. Furthermore, these smaller tanks could be placed in more convenient locations. Not having a carburetor the engine could not backfire, further reducing the fire hazard. The exhaust note was lower because of the diesel’s higher expansion ratio. ”

“ It will probably be found that no one of the 4-stroke cycle, or 2-stroke cycle, engines is best for all grades of oil, but rather that each is best for some one grade. The Diesel engine is in a class by itself, its cycle and method of control being somewhat different from the others.
An investigation of the comparative adaptability of gasoline and alcohol to use in internal-combustion engines, consisting of more than 2,000 tests, was made at the temporary fuel-testing plant of the Geological Survey, at Norfolk, Va., in 1907. ”

“ The escaping hot gas from the Diesel motor can be employed for heating, and the by-products which can be obtained from it will, it is estimated, under proper conditions, more than cover the cost of the original fuel, so that the Diesel motor promises to rival the waterfall in future as a producer of the world's power. ”

“ Just when this type of motor will be taken up by automobile designers is difficult to state. The Diesel type of engine has proved so wonderfully successful for large stationary power plants and for marine purposes, and its reliability is so absolute on all grades of fuel, that this motor may solve the failing-gasoline-supply problem. As yet, about 100 horsepower is the smallest unit that has been made in any quantities, but it was recently announced that this type would, in the very near future, be built for motor trucks and other commercial vehicles. ”

“ At low altitudes the diesel uses an excess of air to eliminate a smoking exhaust; consequently at high altitudes, where the air is less dense, the diesel is still able to maintain much of its power. In contrast, the carburetored gasoline engine is sensitive to the fuel-air ratio and thus has no surplus air available at higher altitudes. A malfunctioning carburetor could cause a gasoline engine to cease operating, but an inoperative fuel injector would cause the Packard diesel to lose one ninth of its power, since each cylinder had its own independently operating injector. ”

“ Water, urine, wine, or any other simple liquid you can get in reasonably large quantities will dilute gasoline fuel to a point where no combustion will occur in the cylinder and the engine will not move. One pint to 20 gallons of gasoline is sufficient. If salt water is used, it will cause corrosion and permanent motor damage.
(5) In the case of Diesel engines, put low flashpoint oil into the fuel tank; the engine will not move. If there already is proper oil in the tank when the wrong kind is added, the engine will only limp and sputter along. ”

“ It is doubtful whether there would be any saving if the orthodox engine were operated on a more suitable fuel. Inherently the Diesel engine must stand higher pressures and therefore is heavier per horsepower. A partial solution of this difficulty is the two-cycle operation, which seems almost a requirement if the Diesel cycle is to be considered at all for aircraft. For any normal commercial operation in the United States there seems to be little or no improvement to be had from the Diesel. ”

“ The advantages of compression-ignition, including reduced fire hazard, more efficient cycle, elimination of electrical apparatus and hence of radio interference, elimination of carburetion problems, and other benefits less evident, would seem to outweigh the difficulties encountered in metering and injecting minute quantities of fuel at the proper instant. Although the Diesel engine suffers upon comparison with the Otto cycle engine in flexibility there seems to be a definite field for employment of Diesels and a gradual extension of their use may be predicted. ”

“ The makers claim—as the result of many tests—that with the crude rock-oil (costing in bulk about 2d. a gallon) which it uses, a horse-power can be developed for one hour by this engine for one-tenth of a penny. The daily fuel bill for a 100 h.p. engine running ten hours per day would therefore be 8s. 4d. To compete with the Diesel engine a steam installation would have to be of the very highest class of triple-expansion type, of not less than 400 h.p., and using every hour per horse-power only 1 3 / 4 lbs. of coal at 9s. ”

“ The remarkable efficiency of the Diesel engine is due principally to the extremely high compression pressure, which was from 500 to 600 pounds per square inch. When this is compared to the 60 to 70 pounds compression pressure used with automobile engines it is easy to see where the Diesel gains its efficiency. It is evident that as much depends on the manner in which the fuel is used in the engine as on the calorific value of the fuel. ”

“ THE DIESEL OIL ENGINE, on account of some features peculiar to it, is treated separately. In 1901 an expert wrote of it that "the engine has not attained any commercial position." Herr Rudolph Diesel, the inventor, has, however, won a high place for his prime-mover among those which consume liquid fuel, on account of its extraordinary economy. ”

“ For petroleum as a fuel under boilers in the generation of steam there are numerous substitutes, including wood, charcoal, coal, peat, natural gas, artificial gas, and electricity; as a fuel in internal-combustion engines some demonstrated substitutes are natural gas, artificial gas, benzol, and alcohol, and in the Diesel type of engine certain vegetable and fish oils can be utilized. ”

“ As a final summary of the author’s analysis of the Packard diesel engine, it must be emphasized that although the engine burned a much cheaper and safer fuel more efficiently than any of its gasoline rivals, it was too unreliable to compete with them. Even if it had been reliable, it was too small to be useful to the large transport operators, to whom its fuel economy would have appealed. ”

“ Many Americans remember the diesel cars of the 1970s — they made a lot of noise and they spewed a lot of black smoke. Advances in technology and new rules issued by my administration have allowed us to leave those days of diesel behind. ”

“ Accordingly, when the fuel is injected in a highly atomized condition at some time previous to the piston reaching the end of its stroke, the fuel burns as it comes in contact with the highly heated air, and the greatly increased pressures resulting from the tremendous increase in temperature brought about by this combustion, acting on the pistons, drive the engine, as in the case of the gasoline engine. ”

“ In some cases petroleum is the best available fuel for an engine, essentially much the same as a gas motor. A carburetor, or atomizer, blows the oil into a fine mist almost as inflammable as gas. In small sizes for launches, threshing machines, or work-shops of limited area, the petroleum engine is a capital servant. In sizes of 75 horse-power and upward the Diesel engine is not only the best oil engine but the most efficient heat-motor ever invented. It involves [467] a principle as important as that of Watt’s separate condenser for the steam from his cylinder. ”