Cotton batting

“ The remaining negroes were set at work to shell the corn already gathered. As fast as shelled, it was taken to Waterproof for shipment to market. The plows were left rusting in the furrows, where they were standing at the moment the guerrillas appeared. The heaps of cotton-seed and the implements used by the planting-gang remained in statu quo. The cotton we planted was growing finely. To leave four hundred acres thus growing, and giving promise of a fine harvest, was to throw away much labor, but there was no alternative. ”

“ The foreman asked my opinion upon various points of plantation management, but I deferred making answer until a subsequent occasion. In every case I told him to do for the present as they had been accustomed, and I would make such changes as I saw fit from time to time.
Cotton-picking requires skill rather than strength. The young women are usually the best pickers, on account of their superior dexterity. The cotton-stalk, or bush, is from two to five or six feet high. It is unlike any plant with which we are familiar in the North. ”

“ Under the rock wall, they found a man, dead on his knees, leaning against the wall; his gun, still cocked and deadly, was resting against his shoulder and needing only the movement of a finger to sweep with deadly hail the cotton-bales. ”

“ Although a three-winged beater, running at 1,000 revolutions, will strike the cotton 3,000 times per minute, the two-winged form, running at the higher velocity of 1,500 revolutions, will give the same number of blows. There is, however, the character of the blow to be considered. The smaller diameter in the case of the two-winged enables the higher velocity to be reached, and the blow given is sharp and quick. In addition to this, the smaller circle described by this form of beater causes the blade, after having struck the cotton, to leave it rapidly ”

“ Skillful pickers work with both hands, never touching the bolls, but removing the cotton by a single dextrous twist of the fingers. They can thus operate with great rapidity.
As fast as the bags are filled, they are emptied into large baskets, which are placed at a corner of the field or at the ends of the rows. When the day's work is ended the cotton is weighed. The amount brought forward by each person is noted on a slate, from which it is subsequently recorded on the account-book of the plantation. ”

“ Cotton was ordered to take two machine-guns and dig them in in such a manner in the front line that they would enfilade the enemy's trenches on the left. If the Germans rushed his own position, he was to disable his guns and retire with his men. After fighting valiantly for a time, the enemy charged, whereupon Cotton, instead of retiring, coolly hauled both guns out of their emplacements and turned them on the advancing Germans. He and his men continued firing until all were slain, and lay a heap of mangled flesh about their guns. ”

“ The cotton is now ready for market.
Toward the close of the packing season there are jolly times on the plantation. Fox-hunting and racing are the order of the day. The Southern planter, like the "fine old English gentleman," opens house to all, and all goes "merry as a marriage bell." Sambo rubs up his old musket, and is out after the ducks, while Dinah's shining face wears an extra gloss in anticipation of the holidays. Throughout the holidays there is high festival in the negro quarters. "The shovel and the hoe" are laid down, and the fiddle is continually going. So ends the cotton season. ”

“ They are stealing cotton at a fearful rate. Captain Kellum of Dathaw lost a whole bale a few nights since, and to-day Mr. Williams, who has just come down from R.'s, tells us that the cotton-house has been broken into and one packed bale cut open and about one hundred pounds taken out of it and carried off! This bale belonged to Mr. York. We none of us feel secure against these depredations. ”

“ The white fleecy cotton, reposing like a wreath of snow upon the bronze red skin of the hand and wrist, is gradually carried to its farthest extent one way, whilst drawing from it the long slender thread, the other hand conducts, in an opposite direction, the short thin reed tipped with a piece of ivory or horn that forms the reel, which spinning as it hangs, its effect upon the thread depends upon the slowness or quickness with which the cotton is drawn out. ”

“ Daily in the early mornings he is to be seen casting his eyes down the pod-laden rows of cotton plants, to see if he can count a few ripe open bolls as he stands at the head of a row. If this be so, he knows that his harvest is close at hand, and his pickers must be ready at any moment to begin what is certainly the most tedious and difficult work of the plantation, namely, picking the raw cotton from the bursting bolls. ”

“ The opener, then, is a very powerful machine, being in fact the most powerful used in cotton spinning, and the most important feature of the machine is the employment of a strong beater, to which is fitted a large number of iron or steel knives or spikes. These beat down the cotton and open it at a terrific rate, the beater having a surface speed of perhaps 4000 feet a minute. Various fans, rollers, and other parts are employed to feed the cotton to the beater, and to take it away again after treatment. ”

“ As regards twisting of the roving it must be distinctly understood that when the attenuated strand of cotton issues from the rollers of the first bobbin and fly frame, it has become so thin and weak that it can no longer withstand the requisite handling without being seriously damaged. Hence the introduction of "Twist," which is by far the most important strength-producing factor or principle entering into the composition of cotton roving and yarn. ”

“ This whip, in an unpractised hand, is a very awkward and inefficient weapon; but the best qualification of the overseer of a cotton plantation is the ability of using this whip with adroitness; and when wielded by an experienced arm, it is one of the keenest instruments of torture ever invented by the ingenuity of man. The cat-o'-nine tails, used in the British military service, is but a clumsy instrument beside this whip; which has superseded the cow-hide, the hickory, and every other species of lash, on the cotton plantations. ”

“ From the axle-tree often hung a gourd, or an iron kettle. One man carried a rifle on his pommel. Sometimes, these carts would contain a single bale of cotton, more commonly, an assorted cargo of maize, sweet potatoes, poultry, game, hides, and peltry, with, always, some bundles of corn-leaves, to be fed to the horse. Women and children were often passengers, or travelled on foot, in company with the carts, which were usually furnished with a low tilt. Many of them, I found, had been two or three days on the road, bringing down a little crop to market ”

“ I have seen many abuses of the negroes in my day, both on shipboard and ashore, and the subject turns me hot. Just how the evils of cotton-gathering are to be avoided I do not know. We must wait, I fear, until some clever individual bobs up with a scheme that does away with hand harvesting of cotton. In the meantime the only remedy left us is to vary the work of the men and women who toil at it as much as is possible."
"I wish, Uncle Frederick, you would tell us just how the cotton is gathered," said Mary, who had joined the group. ”

“ It is made out of the leaf of a species of palm-tree, called Coucourite, hard and brittle, and pointed as sharp as a needle. About an inch of the pointed end is poisoned. The other end is burnt to make it still harder, and wild cotton is put round it for about an inch and a half. It requires considerable practice to put on this cotton well. It must just be large enough to fit the hollow of the tube, and taper off to nothing downwards. They tie it on with a thread of the silk-grass, to prevent its slipping off the arrow.
“The Indians have shown ingenuity in making a quiver to hold the arrows. ”

“ As the tree only attains to a height of from twelve to twenty feet, it is difficult to distinguish the tree cotton and the shrub cotton when referred to by travellers.
The cotton plant, in all its varieties, requires a sandy soil. It flourishes on the rocky hills of Hindostan, Africa, and the West Indies, and will grow where the soil is too poor to produce any other valuable crop.
Cotton has always been regarded as indigenous to India, and as the characteristic clothing material of that country, as flax is of Egypt, silk of China, and the wool of sheep and goats of Northern Asia. ”

“ Their beauty, unhappily, is their only recommendation, for the herbage is rough and coarse, and altogether unfit for pasture, and the cotton, so called, is cotton only in name. It cannot be manufactured; the hairs are too straight and too brittle. Instead of twining and entangling, like the filaments of true cotton, they lie rigidly side by side, resembling true cotton merely in their whiteness, and could no more be spun into yarn than slate–pencils could be twisted into a cable. ”

“ It is a season of unusual industry on the cotton plantations, and woe to the planter who is outstripped in his labors, and finds himself "overtaken by the grass." The plow tears up the surplus vegetation, and the hoe tops it off in its luxuriance. The race is a hard one, but industry conquers; and when the third working-over of the crop takes place, the cotton-plant, so much cherished and favored, begins to overtop its rivals in the fields--begins to cast a chilling shade of superiority over its now intimidated groundlings, and commences to reign supreme. ”

“ When the cotton is picked late in the season, there is usually a dense cloud of dust in the lint-room, which settles in and among the fiber. The person who watches the lint-room has a position far from enviable. His lungs become filled with dust, and, very often, the fine, floating fiber is drawn into his nostrils. Two persons are generally permitted to divide this labor. There were none of the men on our plantation who craved it. Some of the mischievous boys would watch their opportunity to steal into the lint-room, where they greatly enjoyed rolling upon the soft cotton. ”

“ More than two thousand years before Europe or England had conceived the idea of applying modern industry to the manufacture of cotton, India had matured a system of hand-spinning, weaving and dyeing which during that vast period received no recorded improvement. The people, though remarkable for their intelligence whilst Europe was in a state of barbarism, made no approximation to the mechanical operations of modern times, nor was the cultivation of cotton either improved or considerably extended. ”

“ The only other distinctive equipment for cotton harvesting comprised cloth bags with shoulder straps, and baskets of three or four bushels capacity woven of white-oak splits to contain the contents of the pickers' bags until carried to the gin house to be weighed at the day's end.
Whether on a one-horse farm or a hundred-hand plantation, the essentials in cotton growing were the same. In an average year a given force of laborers could plant and cultivate about twice as much cotton as it could pick. ”

“ Many of our women, when cotton was at its prime in opening, and before any rain had fallen on it, would select and pick themselves from the bolls that were the longest and fullest of the white fleecy staple, enough for their finest knitting purposes. They would also pick the seed from the white silky locks with their fingers, which would spin a longer, finer thread than if it had been ginned. ”

“ As will have been gathered in a former chapter dealing with the manipulation of the cotton in the mill, between the Carding Engine and the final process of spinning there are other and important stages of preparation, and in these it is seen how in one respect Arkwright's method of drawing out cotton by revolving rollers was immeasurably superior to the travelling carriage of Hargreaves.
The strength of a rope is represented by its weakest parts, and the same may be said of yarn. ”

“ He allowed, in his machine, the roving to fall into a rapidly revolving can which stood upright; the revolution imparting twist to the cotton. When this can was filled, it was carried to a winding frame, by which the roving was wound upon bobbins suitable for the spinning frame. ”

“ Unlike the bobbin and fly frames, the roving or yarn is not wound on its cop or spindle as it is delivered, but a certain definite and regulated length of cotton is given out to each spindle, and fully twisted and attenuated before it is wound into a suitable shape for transit and for subsequent treatment. ”

“ Mrs. McGregor predicted. "Every tree and bush is laden already."
"The little shrubs in the park look like cotton bushes," replied Uncle Frederick over his shoulder. "Look, youngsters! You were asking about cotton when it is ripe. That is much the way it looks." He motioned toward the vista of bending foliage.
"How pretty it is!" said Mary.
"And in reality cotton is prettier by far, for there is always the blue of the sky, the gold of the sunshine, and the green of the country. It is as if one had a snowstorm in summer." ”

“ Cotton for the first time was here invested with belligerent rights, from its use by General Jackson and his six thousand troops as breastworks. It has ever since been roundly employed by American ladies in the same way against their ardent admirers. The result in the latter case, however, has usually been, not to repel but to heighten the vivacity of the attack; and, unlike that at New Orleans, to procure the surrender of the party with the cotton-works. ”

“ The movement of the cotton trade, like that of civilisation, has ever been westward. India is recognised as having been from time immemorial its home, and although there cotton has probably been in use for ages as clothing, there is no evidence to show that the substance was even known in Europe till the tenth, or that its manufacture was commenced in England till the end of the sixteenth, century. At that time the weavers used yarn made from “cotton wool,” as it was called, but which yarn was furnished by the Levant and only used for weft, linen forming the warp. ”