Sewage treatment plant

“ For example, in one treatment plant the sewage would first pass through a grit chamber where the coarse sediment would be removed, then through a screen where the floating matter and coarse suspended matter would be removed, then to a sedimentation basin where some finer suspended matter might settle out, then to a digestive tank where the solid matter deposited would be worked upon by bacterial action and partially liquefied. ”

“ The pollution of the Bay was therefore so objectionable that careful treatment of the Baltimore sewage has been a necessary preliminary to final disposal by dilution. It is unwise to draw public water supplies, without treatment, from a stream receiving a sewage effluent, no matter how careful or thorough the treatment of the sewage. The treatment of the sewage is a safeguard, and lightens the load on the water purification plant, but under no considerations can it be depended upon to protect the community consuming the diluted effluent. ”

“ Contact units are seldom constructed larger than one-half an acre in area, as larger beds require too much time for filling and emptying. A large number of small units is also undesirable because of the increased difficulty of control. In general it is well to build as large units as are compatible with efficient operation, elasticity of plant, and which can be filled within the time allowed at the average rate of sewage flow, or from dosing tanks in which the storage period is not so long as to produce septic conditions. ”

“ The third state in the biolysis of sewage is the oxidation or nitrification of the products of decomposition resulting from the putrefactive state. The products of decomposition are converted to nitrites and nitrates, which are in a stable condition and are available for plant food. It must be understood that the various states may be coexistent but that the conditions of the different states predominate approximately in the order stated. In the biolysis of sewage there is no destruction of matter. ”

“ In addition to this it must be understood that, owing to the great losses by evaporation and by growing plants, which are continually at work on sewage farms, especially during the summer months, when, as a rule, the flow of water in the brook that takes the effluent is smallest, the quantity of the effluent from the natural treatment is probably only from one-half to one-third that resulting from the artificial treatment, which is a point of very great importance. ”

“ For who would deny that masonry or concrete tanks and the materials contained in the same are artificial products—i.e. products formed by man—and that land is a natural product—i.e. formed by nature—and that further the soil is the natural home of bacteria. Hence it must be perfectly clear, even to a casual observer, that the line of demarcation drawn by the Commissioners between all known systems of sewage purification is a correct and legitimate one, and that all objections to such a division are based on misconceptions. ”

“ This is a matter of vital importance, because when sewage is intermittently applied to land of any kind or to coke beds, vegetation of some kind or other must result and must be removed in order to leave a clear course for the next dose of sewage; the cost of removal and destruction of weeds will be found very great when contact beds are tried on any working scale and would be quite prohibitive if allowed to grow on irrigated land. ”

“ The matters in solution will partly, after removal out of the liquid, be retained by the absorbing powers of the soil in the pores, a process that is due to physical and chemical agencies.
Absorbing powers gradually ripen.
It is well known that land which is being treated with sewage for the first time does not purify sewage so well as land that has been under systematic treatment for some time, and this is probably due to the absorbing powers, which gradually ripen until they have reached their maximum of efficiency. ”

“ For sand filters, either natural or artificial, the tank must be emptied as with sub-surface irrigation, and, in addition, the surface must be scraped occasionally, and at the approach of winter furrows must be dug. Perhaps two days’ time would be all that would be needed for a plant dealing with the sewage of a single family. A broken-stone bed requires no attention for seven or eight years, and then the stone has to be shovelled out, washed, and replaced. ”

“ Experiments have also been made at the Cleveland station where it was found that the sewage sludge contained about one-half as much nitrogen and one-third as much phosphates as does the garbage tankage.
Management and Supervision No matter how well a sewage disposal plant is designed or constructed it will not do its work in a satisfactory manner and produce desired results unless it is efficiently managed. Every plant should be in charge of a man who has knowledge of sewage disposal principles, is thoroughly familiar with his plant and who can act intelligently in an emergency. ”

“ When considering natural and artificial sewage treatment, it ought to be borne in mind that in the natural treatment we have to deal with one treatment only, and that, in order to bring the results obtained from artificial processes up to the same standard, the artificial treatment ought to be supplemented by a treatment for the removal of nitrates from the effluent, and another for the removal of pathogenic micro-organisms, which means one treatment in natural, as against three separate treatments in artificial purification. ”

“ Among the principal objections to the combined system when the sewage is treated are the increase it causes in the volume of liquid which necessarily requires a larger plant and expenditure, the changes it causes in the character of the sewage which complicates operation of the plant, and the frequency with which it causes the flow of sewage to exceed the maximum of the plant, thereby making it necessary to discharge untreated sewage into the stream. With a combined system all kinds of trade wastes must be run through the disposal plant, whether they are offensive or not ”

“ Material left over has to be hauled away, and in order to leave the plant in an attractive dress, seeding or sodding the earth slopes is desirable. It is even desirable to plant shrubbery around the edges of the beds, partly as a screen and partly to minimize the offensive suggestions which seem to be inseparable from any plant dealing with sewage. The cost of these final improvements may be as little or as much as the owner and builder chooses, but it is urged that their value should not be overlooked. ”

“ If the volume of diluting water, or the area and character of land used for disposal are not as they should be, a nuisance will be created. The aim of all methods of sewage treatment has so far been to produce an effluent which could be disposed of without nuisance and in certain exceptional cases to protect public water supplies from pollution. Financial returns have been sought only as a secondary consideration. ”

“ It may be done by discharging the tank effluent into a system of agricultural drains laid just below the surface of the ground, called sub-surface irrigation. It may be done by removing the top soil from a bed of sand placed by nature, and needing little except suitable surface distribution to insure the most efficient purification.
For a small plant, instead of a sand filter, for which the sand is found naturally in a suitable location, an artificial filter may be built by preparing an enclosure and carting in sand for filling. ”

“ Before any sewage scheme is conceived a very careful survey of the neighbourhood ought to be made by a person who knows the requisites of a site for sewage disposal, especially if land irrigation is intended, because natural advantages of site both for tanks, main carriers, roads, etc., may make all the difference in the world in expense and efficiency not only in first cost of works but also in their use afterwards. ”

“ They do, however, suggest that for communities where clarification and disinfection are desirable—where screening would be insufficient and nitrification unnecessary—the process of acid treatment comes fairly into competition with the other processes of tank treatment, and that it is particularly suited to dealing with sewages that contain industrial wastes, and to use in localities where local nuisances must be avoided at all costs and where sludge disposal could be provided for only with difficulty. ”

“ Passing now to the aerobic stage of sewage purification we find it universally admitted, that a good loam resting on very porous sand or gravel, affords the best medium for work by the oxygen-loving nitrifying organisms [Pg 6] when they are supplied with constantly moving liquid sewage, and given intermittent periods for the aeration of the pores of the soil. ”

“ An interim report by Lord Iddesleigh’s Royal Commission has, however, awakened such theorists to the fact that land is not to be discarded because it may not bring in a profit or because patentees of systems find it to their interest to contrast neglected or badly managed sewage farms with carefully nursed little experimental installations for artificial treatment of selected samples of sewage. ”

“ It produces a better effluent than any other known process of sewage treatment except land treatment or intermittent sand filtration; it can be built upon a comparatively small area; it produces no objectionable odors or flies; it produces a sludge of sufficient value to meet the cost of its reduction to a fertilizer and therefore relieves the city of the difficult, complicated and wasteful method of sludge disposal common to all other processes ”

“ Where no sand is available, or where its use would be uneconomical, broken stone may be used to ensure final treatment. With stone, on account of its large voids, the enclosure must either be water-tight, and the outlet pipe must be provided with 13a valve or other device so that the sewage under treatment may be held in the enclosure or tank long enough to deposit the solids in suspension and to be acted on by the bacteria concerned. ”

“ No chemicals should be used in a septic tank; garbage, rags, newspaper, and other solids not readily soluble in water should be kept out of sewers and tanks. The plant should be inspected often, noting particularly if the siphon is operating satisfactorily. If scum forms in the settling chamber it should be removed, and the sludge should be bailed or pumped out yearly. Frequently tanks are not cleaned out for three or four years, resulting in large quantities of solid matter going through to the distribution system and clogging it. ”

“ Where such a filtration area is made to form part of a sewage farm it acts as a safety valve, and enables the land and crops to have a rest when they do not require further irrigation; at the same time the process of purification is not interrupted. If open, porous land is available for sewage purification, and if it can be drained 6 ft. deep to a good free subsoil, so that the effluent can get readily away, we find that the sewage of from 600 to 700 people can be dealt with on each acre per annum with both good agricultural and sanitary results. ”

“ The Crop.—From a sanitary viewpoint no crops which come in contact with the sewage should be cultivated on a sewage farm. Such products as lettuce, strawberries, asparagus, 464potatoes, radishes, etc., should not be grown. Grains, fruits, and nuts are grown successfully and as they do not come in contact with the sewage there is no sanitary objection to their cultivation in this manner. Italian rye grass and other forms of hay are grown with the best success as they will stand a large amount of water without injury. ”

“ The main purpose of home sewerage works is to get rid of sewage in such way as (1) to guard against the transmission of disease germs through drinking water, flies, or other means; (2) to avoid creating nuisance. What is the best method and what the best outfit are questions not to be answered offhand from afar. A treatment that is a success in one location may be a failure in another. In every instance decision should be based upon field data and full knowledge of the local needs and conditions. An installation planned from assumed conditions may work harm. ”

“ While there have been some demands for the absolute sterilization of sewage, many sanitarians believe that any artificial method of sewage treatment will not esthetically render the final effluent fit for ingestion, and practically all authorities agree that final discharge of sewage need not be in this perfect condition. ”

“ He does not believe that under proper treatment sludge is capable of clogging the pores of the land or of injuring vegetation. He advises the laying out of the filtration-beds in ridges and furrows, the sewage only to flow into the furrows and not to be allowed to flood the ridges on which plants and vegetables are growing. As soon as the deposit of sludge on the sides of the furrows is sufficient to prevent infiltration in any great degree, the sewage should be withheld from the areas so affected. ”

“ About the only plants of any importance in the United States are those at Worcester, Massachusetts, and Providence, Rhode Island. According to the report of the Superintendent of Sewers of Worcester, the experimental plant in that city has shown that “the cost of operation of Imhoff tanks and sprinkling filters per million gallons of sewage treated would be much less than the cost of operation of chemical precipitation or sand filtration as carried on in Worcester.” ”

“ How extremely simple it all is!” was the remark of a recent visitor at a sewage farm—which encourages me to venture on publication of the most recent discussions on a “problem” complicated by engineers, chemists, bacteriologists and inventors of systems, who have raised clouds of dust through which it is difficult for ratepayers and district councillors to find their way to “the best practical and available means of sewage disposal.” ”