Letterpress printing

“ This last book shows that unknown or not Faques was a skilful printer, for it is one of the most beautiful books issued from the early English press. The type is sharp and brilliant, the printing in red well done, and each page is surrounded with a chain-like border. On the first leaf is the printer’s device, a very uncommon one, [Pg 170] consisting of two triangles. ”

“ A knowledge of paper in this thorough sense is even more desirable if a printer presumes to arrogate to himself the title and qualities of an artist. It is scarcely too radical to assert that the esthetics of printing depend for exemplification more upon paper than upon typography. It has been said that type, ink, and paper go to the making of good printing. This formula may be reversed and made to read paper, ink, and type, since so much of the effect of decorative printing depends upon the paper and the ink. ”

“ Once the printer or his apprentices had set the type, pulled a proof, “made up” the type into pages with the proper spacing and ornaments, and then locked it into forms by means of furniture and quoins, he placed his form on the press and adjusted it to get the most even impression. Then he was ready to begin the actual process of printing. Whereas printing is commonly done today by automatic presses, fed with paper either mechanically or by hand, it had to be done one sheet at a time in the eighteenth century. ”

“ But the modern printer, as a rule, dumps down the page in what he calls the middle of the paper, which is often not even really the middle, as he measures his page from the head line, if he has one, though it is not really a part of the page, but a spray of type only faintly staining the head of the paper. ”

“ Such presses are capable of turning out about 250 impressions per hour, and it should be noted that the very finest book printing is still done by presses upon this principle. One reason is that in such cases, where it is desired to print with the greatest clearness and depth of colour, the ink employed is much thicker, or stiffer, and requires more thorough distribution and application to the type than a machine can effect. ”

“ LITHOGRAPHING.—Lithography, like copperplate, requires a special press, but a secondhand press can be bought for $25 or $30, and it is certainly the cheapest process known for short runs of pictorial color work; and any printer who has many orders for posters or picture printing would do well to investigate the process; for it is not difficult to draw on the stone, and, after the stones are bought, they last for years, and every new design simply necessitates the scouring off of the previous design, which will take a boy only about an hour. ”

“ Type is type, speaking somewhat loosely, and, whatever the crotchet a consumer of printing may get into his head it is not likely to cost more than about so much a pound. It is otherwise with paper, and generally it is more the color, texture, and appearance the patron wishes than the intrinsic value, and the printer must make a choice that shall satisfy the artistic exigencies of the case, as well as consider its financial aspects. One paper may be unsuited for a particular piece of work, and another of the same tint, weight, and price may be exactly suitable ”

“ If the print is large (say 15 by 12) it is not advisable to look at much of it at once, or for a longer time than can be avoided. It constantly happens that on a warm day the paper contracts during the short time necessary for a proper examination of the print; the consequence is, that the paper does not fall on the same place on the negative when reflected, and the result is a double print on the paper.
The printing being judged to be complete, the paper is withdrawn by taking off pressure-board and pads, and put away for the further operations of toning and fixing. ”

“ When we note the important part played by paper in the complicated scheme of our twentieth century lives, we may gain some faint appreciation of its place and relative importance as a factor of life. As a factor in printing it has been customary to place paper first in the list. It is a safe practice, though the versatility of the paper makers is yearly making it less essential to do so. Yet, when all the progress in paper making has been considered, it paradoxically remains that the selection of paper by the printer is not the simple matter it was only a few years ago. ”

“ The name of the printer, the author, and the publisher was to be placed in every book, and, with a view to encouraging English printing, it was decreed further that no merchant or bookseller should import any English book printed abroad. No person was to erect a printing-press, or to let any [Pg 179] premises for the purpose of carrying on printing, without first giving notice to the Company, and no joiner or carpenter was to make a press without similar notice. ”

“ You can make a printing press out of wood but to do a good job you must have a press built of iron and properly machined, that is finished up, for to do good printing a good outfit is needed to begin with.
Small hand inked and self-inking presses are sold in the toy departments of nearly all stores at prices ranging from $1.50 to $5.00 and this will include a font of type. Many of these little presses are made which use type about half the length of regular type and if you get a press of this kind you will never know the real joy of printing. ”

“ General Magazine advertising of paper has been principally devoted to writing paper. This is natural, since of all paper products this commodity has the largest number of buyers, and the matter of taste is not so over-shadowed by technical considerations, as in the case of printing papers.
The specifications for general printing, involve more knowledge of printing processes than most people possess, hence the final decision rests in a majority of cases on the printer’s judgment, so that logically the printer is the most necessary individual to convert. ”

“ The art of printing has attained to a marvelous degree of progress. Hoe's printing-press, moved by steam, seizes on the blank paper, severs it from the roll in sheets of the right size, prints it on both sides, and folds it in a convenient shape,—all with miraculous rapidity. ”

“ The printing is effected by steam-worked presses. The ink is blue, and its composition known only to a few of the authorities. An inspector goes his rounds during the continuance of the operations, watching every press, every workman, every process. A beautiful machine, distinct from the press, is employed to print the variable numbers on the note; fed with sheets of paper, it will number a thousand of them in succession, changing the digits each time, and scarcely requiring to be touched meanwhile; even the removal of one note and the placing of another are effected by automatic agency. ”

“ Now the chief marvel of a modern combined printing press is its power of being used to print separately a large number of small sized papers or by leading the paper through the press in a slightly different way to print a mammoth paper folded all together and receiving contributions from all six reels at once. In the particular machine in question, which is used to print a comparatively small sized paper, any six of the separate machines can be run separately, if a small paper and a small output only is wanted. ”

“ It must be remembered, however, that most modern printing is done by machinery on soft paper, and not by the hand press, and these somewhat wiry letters are suitable for the machine process, which would not do justice to letters of more generous design. ”

“ Modern printers, even the best, pay very little heed to these two essentials of seemly composition, and the inferior ones run riot in licentious spacing, thereby producing, inter alia, those ugly rivers of lines running about the page which are such a blemish to decent printing. ”

“ It is not always easy to persuade the consumer to select the very best paper for office stationery, but the choice should be made with a view to create a good impression. Remember always, too, that printing demands good paper to produce the most satisfactory effect.
For lithography the work in hand frequently dictates the quality of paper to be used. Offset printing, certainly, has enabled the lithographer to print on papers unsuitable for direct stone printing, but in all work the right paper produces the best result. ”

“ It is not the mere exhibition of this sort of knowledge that particularly signifies; it is that it adds greatly to the printer's power to execute good work, as it places him in a position to select the most suitable paper, and insures his reputation. It enables him to execute a piece of work intended to endure a long time in a manner that will preserve its beauty, so that it will not fade or turn a dirty brown or yellow color, as well as to make his paper play its legitimate rôle as the most important inflexible art element91 he will usually find it necessary to deal with. ”

“ The readable method of doing presswork is, unfortunately, out of fashion. A perverted taste requires the modern printer to use thin types, dry glossy paper, as little ink and as weak an impression as is consistent with passable legibility. ”

“ CHAPTER XI THE PRESENT CENTURY
t has been said that printing sprang into the world fully armed. At least this is certain, that for nearly four centuries after its birth the printing-press in use in all printing-houses remained the same in form as that which Caxton's workmen had used in the Red Pale at Westminster. There had been some unimportant alterations made in it by an Amsterdam printer in the seventeenth century; but until the year 1800 no important change in the form or mechanism of the printing-press had ever been introduced. ”

“ This three-colour process has been a rather long time in establishing itself and nothing has so tended to retard it as bad printing. Good blocks have been obtainable, but in the hands of ordinary printers they have yielded but indifferent results. It is hardly to be expected that the untrained eye of the ordinary printer should be successful where the work requires the cultivated judgment of an artist. There is one other necessity for success in all tone relief work, and that is the use of the right quality of paper and ink. ”

“ Ink is taken from the type more readily by paper of this kind, especially if the latter be rather soft in texture, so that the press drives into it the face of the type bearing the ink. Modern processes of reproducing pictures give plates for printing, many of which are made up of very fine lines placed very closely together and having very shallow depressions between them. To print from these with good results the paper used must have a very smooth, highly polished surface. The press drives soft paper down into the narrow places between the fine lines and blurs the impression of the cut. ”

“ Visitors to the Printing Office today may not see counterparts of the postriders who brought mail to Parks’s printing shop and post office, but nearly everything else is there. As in colonial days, the central figure is still the printer, bending over his press and producing in a day’s work what one modern, mechanized press can turn out in a few minutes. ”

“ As we have seen, the typical book during the first quarter of a century of the history of printing is one in which the printer supplied the place of the scribe and of the scribe alone. An appreciable, though not a very large, percentage of early books have come down to us in the exact state in which they issued from the press, with a blank space at their beginning for an illumination, blanks for the initial letters, blanks for the chapter headings, no head-lines, no title-page, no pagination, and no signatures to guide the binder in arranging the sheets in the different gatherings. ”

“ The presswork is decidedly inferior: the deeply indented paper shows that the printer could not regulate the pressure on the types; the muddiness of the letters comes from the use of a thin ink, and the faulty register from a shackly press. The colophon or subscription of this book, a translation of which is submitted, specifies the date, the place of printing and the printer:
Every man, in his heart, desires to be learned and well read. Without books and without teacher, this cannot be. ”

“ The general solidity of a page is much to be sought for: modern printers generally overdo the “whites” in the spacing, a defect probably forced on them by the characterless quality of the letters. For where these are boldly and carefully designed, and each letter is thoroughly individual in form, the words may be set much closer together, without loss of clearness. No definite rules, however, except the avoidance of “rivers” and excess of white, can be given for the spacing, which requires the constant exercise of judgment and taste on the part of the printer. ”

“ While there are versatile artists like Will Bradley who can do good work in many styles, they are not numerous.
Some printers retain typographic artists who serve clients by the hour. These artists sometimes are advertising writers who have studied the art side of printing and know that much depends upon the type-face used.
To plan a booklet properly the commercial printer must know something of the principles of art and advertising and of good book typography. Booklet printing is really the connecting link between job printing and book printing. ”

“ We can already do so in three, and by the same number of machinings we can reproduce such pictures in print, provided we can afford to print slowly enough and on a sufficiently smooth paper. The process is in its earliest infancy as yet. We shall ultimately make it far more practicable. But even so, printing presses of the present sort are far too slow for newspaper use. A hundred years hence magazines and weekly periodicals may perhaps still be printed on greatly improved presses; but daily papers will be produced by photography alone. ”

“ Every boy, at one time or another, gets an attack of printers’ fever, and then he will not be satisfied until he makes or purchases a printing-press. There are, of course, many different kinds of printing-presses. One of the simplest forms is shown in the drawing of the flat-bed press (Fig. 1) , which is very easy to make and to manipulate. A flat board one and one-half inches thick, twelve inches wide, and eighteen inches long will form a substantial bed on which to fasten the frame and pressure-plate. ”