Cotton industry

“ Speeds have certainly gone up a good deal of late on some counts. And it is quite likely, too, that concentration on the manufacture of coarse goods for export, with stout warps to keep down the breakages and raise the output per loom, may be reckoned as one cause.
Despite the recent sensational growth in the South, the New England States still remain the most prominent seat of the American cotton industry. ”

“ Introduction of simple, animal-drawn cultivators, with practical instruction on their use to be given to large planters of cotton in the interior. “3. Stimulation by the Government of all activities related to the cotton industry, and suspension for some years of all connected taxes and duties. “Extensive propaganda in favor of cotton growing is being animated by the far-seeing and incomparable activity of Dr. Miguel Calmon. If this work is continued in all parts of the country where cotton is cultivated there is no doubt of success. ”

“ It has gone on increasing rapidly until the whole crop may now, perhaps, in a season of great product and great prices, amount to $100,000,000.” According to the estimates of the United States Census Bureau in its census of 1900, cotton production increased from 2,000,025 pounds in 1790 to 987,637,200 pounds in 1849, and 2,397,238,140 pounds in 1859. The enormous capital invested in this industry created a close community of interest between the planters of the South and the capitalists of the North; hence the influence of the cotton trade was felt in both sections. ”

“ Even so, it appears that in British cotton mills ring-spindles are increasing at a greater rate than mule-spindles, and in the mills of other countries the fact is more pronounced. Whether the above figures represent a permanent tendency a longer period will be required to show, but, in any [Page 165] case, it is certain that the development of the cotton industry during the past century and a half, particularly in the United Kingdom, cannot be fully understood apart from the service which has been rendered by the invention of Samuel Crompton. ”

“ COTTON.—Reviewing the work which has been done in inducing the agricultural population of the country to cultivate cotton for export, by far the greatest prominence must be given to the untiring efforts of the British Cotton Growing Association, who are gradually surmounting all the obstacles which retarded their progress. The condition of the industry, especially in the Western Province, is extremely favourable, and shows signs of further development. ”

“ This has for its object the combination of the warp and weft yarns, interlacing one with the other in such manner as to produce a firm texture, fitted for the varying uses to which cotton cloth is adapted—for warmth, for ornament, for trade purposes—for sale. The power looms of the present day, as employed in the cotton industry, vary very little in construction in the most widely separated districts, unless for very different classes of work, then what modifications are required consist of extra mechanism added to our common type—the plain loom. ”

“ Capital and labor, in Europe and America, are largely employed in the manufacture of cotton. These goods, to a great extent, may be seen freighting every vessel, from Christian nations, that traverses the seas of the globe; and filling the warehouses and shelves of the merchants over two-thirds of the world. By the industry, skill, and enterprise employed in the manufacture of cotton, mankind are better clothed; their comfort better promoted; general industry more highly stimulated; commerce more widely extended; and civilization more rapidly advanced than in any preceding age. ”

“ Easy yielding to the principle did not suggest to the great bulk of the South's statesmanship the reflection that the section after all was in only partial compliance; that even for the most efficient production of cotton as such, there needed to be a wholesome admixture of manufacturing and of other agricultural interests. Accompanying and directly by agency of the post-bellum activities in industry is seen not a less but a more economical and larger output of the staple. ”

“ They have already enabled Mr. Daniels to cast much new light [xx] on the vicissitudes of the cotton trade during the revolutionary and Napoleonic wars, and he hopes in time to illustrate by their aid many aspects of the cotton industry during the most important period of its development. ”

“ The growing of cotton is not a raw-material industry in the strict sense of the word, for, owing to peculiarities of climate, certain features of the American labor supply, and the great amount of money this staple crop brings from abroad and distributes in non-manufacturing districts, it possesses a peculiar and great economic value to the country. Coal, tobacco, petroleum, and timber are the more important of the crude materials exported from the United States in addition to cotton ”

“ The other countries of Europe have developed a spinning industry by no means inconsiderable. American cotton is sent to almost all those European countries which spin and weave.
Such a movement had of course a profound effect upon the currents of world trade. The cotton crop is the second in value of all the crops produced in the United States, and such a large part of it is exported that the credit it gives to its sellers enables them to buy in return some of the most valuable of the products manufactured in Europe. ”

“ For instance: "When we consider that the takings of the Continent from Lancashire are not piece goods, but yarns, why cannot we in the South make these yarns for the Continent ourselves and save to ourselves the profit of conversion now enjoyed by the English buyer of the raw material? Why not have a large and successful cotton manufacturing industry?
"We are persuaded that once the folks in New England, who have surplus money awaiting employment, thoroughly investigate the points Richmond presents for a safe lodgment of that capital in manufacturing, the flow will start this way." ”

“ One witness asserted that he and his brother employed upwards of 600 looms in the weaving of fustians, and as one weaver required four spinners to supply him with yarn, he computed that upwards of 3000 persons were dependent upon them for employment—a striking case of large-scale production, in the sense of numbers employed, nearly forty years before the appearance of the factory in the cotton industry. ”

“ In the article of cotton, which is our great manufacturing staple, America has the inestimable advantage of growing the raw material—an advantage which never can be counterbalanced, as, even if we were to obtain our supplies from some other quarter, the expenses of freightage must still continue to be great. In fact, to all appearance, our supremacy in the conversion of cotton is already doomed. That branch of industry rests upon no substantial basis. ”

“ On a Moderate calculation the Invention has given employment for many years to thousands of Machine makers and Spinners, and perhaps to 50,000 Weavers and in the agregate reconing from the raw material not less than 300,000 Men, Women & Children, its extencive use has caused the increased growth and import of cotton to an immence extent to the great advantage of landowners, merchants, and planters. ”

“ In the four hundred pounds of lint in a bale of cotton there are but four pounds of chemical elements taken from the soil; in the oil there is little more; but in the seed-cake and hulls there are forty pounds of potash and phosphate of lime. But admirable as is the disposition of the cotton seed for manufacture, ample as is the margin of profit, and rapid as has been the growth in the industry, there exists the same disorganization that is noticeable in the handling of the whole cotton question. ”

“ It is calculated that an Indian power-loom weaver working 72 hours a week can turn out 70 ℔ of cloth, while a European working 54 hours can turn out 468 ℔, and that one Lancashire weaver can do the work of six Indian power-loom weavers and nine hand-loom weavers. While these figures hold good, India cannot be a serious competitor with Europe in the cotton industry.
Jute.—Next to cotton, jute is the most important and prosperous of Indian manufactures. With the advance of commerce it is more and more required for its best-known use, as sacking for produce. ”

“ In two field investigations in the South, many gentlemen connected directly or indirectly with the cotton manufacturing industry have been instituting in extending their time and counsel and courtesy. ”

“ Before the end of the century, cotton from the British plantations had assumed a prominent place, and from this time the European West Indian colonies, with South America, became the most important sources of supply until the end of the eighteenth century, when they in turn were displaced by the United States. ”

“ A banker who is intimately connected with the textile industry in one of the oldest industrial communities in the South and who is a member of a family to which many writers are quick to point as founders of cotton manufacture in the South through agency of conspicuous participation in the business since the early thirties, said: "The mills built after the war were not the result of pre-bellum mills. ”

“ In the petition it was stated that before the beginning of the dispute with the American colonies the cotton manufacture in Lancashire had employed thousands of men, women and children, but of late years it had much decreased, and the workpeople were destitute of employment and in extreme distress. ”

“ A typical notice is this one: "The enterprising citizens of the new town of Gaffney City have subscribed $40,000 towards building a cotton factory at that place." [203]
[Pg 151] Columbus, Georgia, was held up to praise for her loyal support of the cotton manufacturing industry. Before the war she was a little Lowell, it was said. The Federal army captured the place in 1865 and burned 60,000 bales of cotton and all the mills. "The very heart of the city was burned out, but nothing could extinguish its indomitable spirit." ”

“ William Gregg, Essays on Domestic Industry, p. 8. Nothing is more frequently remarked as indicative of the exclusive attention to the cultivation of cotton than the large reliance of an almost purely agricultural country upon other sections for many articles of food. And not only subsistance for the people, but subsistence for the plantation as such often had to be imported. Missing nothing, Olmsted said, in a description of a rail journey in North Carolina, "The principal other freight of the train was one hundred and twenty bales of Northern hay. ”

“ In the evidence on the petition [89] a strong case was presented on behalf of merchants engaged in foreign trade—particularly in the import of cotton—and of fustian manufacturers, it being stated that several thousand persons from five to seventy years of age were employed in the manufacture. ”

“ Of the negotiations in London immediately preceding the grant eventually made to him a clear account is given in the following letters.
With a view to the application, he collected information of the extent to which the mule was used and of its effects upon the cotton industry in England, Scotland and Ireland, and on the basis of this information a [Page 154] petition was prepared for presentation to Parliament. [460] To ensure its being influentially signed, Mr. Kennedy and Mr. ”

“ And with regard to internal policy, "Perhaps the most striking economic change that the new [Pg 48] industry (cotton culture) effected in the South after the reintroduction of slavery was the speedy abandonment of manufactures ... what was the use of nerve-racking investment in elaborate and costly machinery when a land-owner could reap ten per cent net profit from a few negroes and mules and a bushel or two of the magical cotton seed? and yet the South had unusual manufacturing facilities ... manufacture soon fell into decay ”

“ At the outset, most conditions were favorable to large gains—there was little competition, labor was most plentiful and cheap, the lack [Pg 251] of advantageous marketing facilities was to some degree offset by purely local demand for the product, and the deficiencies of management tended to be neutralized by the presence of physical advantages which disappeared when a more advanced development increased the size of plants, widened the area from which raw cotton was drawn, and extended the market for product. ”

“ There is a far higher remuneration than has ever been given by cotton yet in store for the laborer, the manufacturer, the South and the entire country. In the midst of the cotton plantations themselves there is a career for manufacturing development such as the world has not yet seen. With coal, iron and timber in perfection and inexhaustible, and water power everywhere, by what rule of political economy should the Southern people send their cotton, at an expense always deducted from its price, to distant sections and foreign countries to be spun and woven? ”

“ It only remains for us to refer summarily to the factors of supply. It is practically certain that the South will continue to produce the bulk of the world’s cotton. During the Civil War, when cotton was over $1.00 a pound, persistent efforts were made all over the world to develop cotton growing, but in vain. The Gulf Stream on one side, and a vast continent on the other, produce climatic conditions for cotton culture not duplicated anywhere else in the world. ”