Diesel engine

“ Shielding was unnecessary because the diesel had no electrical ignition system. Carburetor icing was an impossibility because there was no carburetor.
Any excess lubricating oil in a diesel engine’s cylinder is consumed cleanly to produce power. By contrast, such oil in a gasoline engine’s cylinder is only partly burned. As a result carbon deposits form that eventually cause malfunctioning of the spark plugs, valves, and combustion chambers. This advantage accrued to the diesel because it utilized an excess of air, and in addition its cylinder walls were hotter. ”

“ In the Diesel engine there is no evaporating of fuel, and no deposits of carbon because of the high temperature of the combustion chamber. With engines that draw the mixture of vapor and air into the cylinder there are several methods of applying heat to the liquid, and the combustion of the vapor thus formed is perfected by the injection of water into the combustion chamber. It has been found by experiment that a small amount of water vapor introduced into the cylinder of a kerosene engine makes the engine run more smoothly and prevents a smoky exhaust and carbon deposits in the cylinder. ”

“ Diesel Oil Engine. The Diesel engine marks the greatest progress in the internal combustion field made in the last few years. It marks a distinct advance in both thermal efficiency, and in the character of the fuel that it has made a commercial possibility. By the use of cheap fuel heretofore unavailable for any type of prime mover, such as the asphaltum residual oils, coal tar, etc., it has lowered the cost of power production to a point where it is unapproached by any type of heat engine. ”

“ It is this requirement in a gasoline engine that necessitates an accurate and sensitive fuel-and-air metering device known as the carburetor.
The fact that the air supply of a Diesel engine is compressed and its temperature raised to such a high degree permits the use of liquid fuels with a high ignition temperature. These fuels correspond more nearly to the crude petroleum oil as it issues from the wells and this fact accounts for the much lower cost of Diesel fuel as compared to the highly refined gasoline needed for aircraft engines. ”

“ It is doubtful whether there would be any saving if the orthodox engine were operated on a more suitable fuel. Inherently the Diesel engine must stand higher pressures and therefore is heavier per horsepower. A partial solution of this difficulty is the two-cycle operation, which seems almost a requirement if the Diesel cycle is to be considered at all for aircraft. For any normal commercial operation in the United States there seems to be little or no improvement to be had from the Diesel. ”

“ In some cases petroleum is the best available fuel for an engine, essentially much the same as a gas motor. A carburetor, or atomizer, blows the oil into a fine mist almost as inflammable as gas. In small sizes for launches, threshing machines, or work-shops of limited area, the petroleum engine is a capital servant. In sizes of 75 horse-power and upward the Diesel engine is not only the best oil engine but the most efficient heat-motor ever invented. It involves [467] a principle as important as that of Watt’s separate condenser for the steam from his cylinder. ”

“ As a final summary of the author’s analysis of the Packard diesel engine, it must be emphasized that although the engine burned a much cheaper and safer fuel more efficiently than any of its gasoline rivals, it was too unreliable to compete with them. Even if it had been reliable, it was too small to be useful to the large transport operators, to whom its fuel economy would have appealed. ”

“ It will probably be found that no one of the 4-stroke cycle, or 2-stroke cycle, engines is best for all grades of oil, but rather that each is best for some one grade. The Diesel engine is in a class by itself, its cycle and method of control being somewhat different from the others.
An investigation of the comparative adaptability of gasoline and alcohol to use in internal-combustion engines, consisting of more than 2,000 tests, was made at the temporary fuel-testing plant of the Geological Survey, at Norfolk, Va., in 1907. ”

“ Of course the power is not doubled or increased, because each piston moves only half as far as it would for a given expansion of gas were it operating in a cylinder closed by a cylinder head.
The efficiency of Diesel engines, although greater than that of the gas and gasoline engines, is still very low. The semi-Diesel will yield about 30 per cent of the energy in the fuel, the Junker engine about 34 per cent, and the best Diesel, four-cycle engine in large units, about 36 per cent. ”

“ The advantages of compression-ignition, including reduced fire hazard, more efficient cycle, elimination of electrical apparatus and hence of radio interference, elimination of carburetion problems, and other benefits less evident, would seem to outweigh the difficulties encountered in metering and injecting minute quantities of fuel at the proper instant. Although the Diesel engine suffers upon comparison with the Otto cycle engine in flexibility there seems to be a definite field for employment of Diesels and a gradual extension of their use may be predicted. ”

“ This brings about the necessity for injecting the fuel in a well-atomized condition at the time that combustion is desired and the quantities of fuel injected at this time control the amount of heat generated; that is, an infinitesimally small quantity of fuel will be burned just as efficiently in the Diesel engine as a full charge of fuel, whereas in the gasoline engine the mixture ratio must be kept reasonably constant and, if the supply of fuel is to be cut down for throttling purposes, the supply of air must be correspondingly reduced. ”

“ A further weight saving resulted from the use of a single valve for each cylinder instead of two as in the case of conventional gasoline aircraft engines. (A diesel engine designed in this manner loses less efficiency than a gasoline one because only air is drawn in during the intake stroke.) In addition to the weight saving brought about by having fewer parts in the valve mechanism, there was an additional advantage since the cylinder heads could be made considerably lighter. ”

“ The remarkable efficiency of the Diesel engine is due principally to the extremely high compression pressure, which was from 500 to 600 pounds per square inch. When this is compared to the 60 to 70 pounds compression pressure used with automobile engines it is easy to see where the Diesel gains its efficiency. It is evident that as much depends on the manner in which the fuel is used in the engine as on the calorific value of the fuel. ”

“ The oil ignites at once as it enters the combustion space, and so a power impulse is obtained, but without explosion. The pressure does not rise above the pressure of air and oil injection. The Diesel engine thus embodies two very original features; it operates at compression pressures very much higher than those used in any other internal combustion engines, and it dispenses with the usual igniting devices by rendering the air charge incandescent by compression. The engine operates generally on the Otto cycle, but it is also built giving an impulse at every revolution. ”

“ The makers claim—as the result of many tests—that with the crude rock-oil (costing in bulk about 2d. a gallon) which it uses, a horse-power can be developed for one hour by this engine for one-tenth of a penny. The daily fuel bill for a 100 h.p. engine running ten hours per day would therefore be 8s. 4d. To compete with the Diesel engine a steam installation would have to be of the very highest class of triple-expansion type, of not less than 400 h.p., and using every hour per horse-power only 1 3 / 4 lbs. of coal at 9s. ”

“ With a given cylinder capacity this heating effect has increased the output about 75 per cent. The loss due to the friction of the scavenging apparatus causes a fuel consumption of approximately 10 percent more than a standard four stroke Diesel.
Unlike the Diesel, this engine automatically controls the quantity of injection air admitted to the cylinder at different loads, the air corresponding with the amount of fuel injected. This is in marked contrast with the Diesel engine which admits a constant volume of air at all loads. ”

“ Unlike the ordinary gasoline engine in which an increase of speed increases the output in an almost direct proportion, the output of the Diesel engine decreases when the speed rises 167beyond a certain limit due to imperfect combustion at speeds much over 350 revolutions per minute. ”

“ In the Diesel motor, on the other hand, the ignition continues as long as fuel is admitted, and thus this engine is of the internal combustion type in the strictest sense of the word. It is, after all, the expansion of the gases due to the heat of combustion that produces the power in a gasoline engine, and if the fuel can be so admitted that it can burn during the greater part of the stroke, a high efficiency will be obtained. ”

“ Just when this type of motor will be taken up by automobile designers is difficult to state. The Diesel type of engine has proved so wonderfully successful for large stationary power plants and for marine purposes, and its reliability is so absolute on all grades of fuel, that this motor may solve the failing-gasoline-supply problem. As yet, about 100 horsepower is the smallest unit that has been made in any quantities, but it was recently announced that this type would, in the very near future, be built for motor trucks and other commercial vehicles. ”

“ In the Diesel engine the drop of pressure in expansion is much more gradual, the indicator diagram expansion curve being nearly horizontal. The uniform pressures thus obtained result in smooth action and even driving power, obtained with no other type of engine. ”

“ Diesel, the inventor of the Diesel engine, is comparable only to Watts in the development of power; but he is not considered of sufficient importance by the editors of the Encyclopædia Britannica to be given a biography. And under Oil Engine we read: “Mr. Diesel has produced a very interesting engine which departs considerably from other types.” ”

“ The advantages of lower fuel cost and greater cruising range offered by the diesel engine would be relatively unimportant to a private pilot flying for pleasure, but would be vital to the commercial operator using airplanes powered by engines having several times the horsepower of the Packard diesel. ”

“ The Packard diesel had the highest maximum cylinder pressure (up to 1500 psi at peak rpm) of any proven contemporary aircraft diesel engine. Leigh M. Griffith, vice president and general manager, Emsco Aero Engine Company, had this to say about the Packard diesel’s high maximum cylinder pressure in the September 1930 S.A.E. Journal:
The designers considered it necessary to adopt unusual but admittedly clever expedients to counteract the great torque irregularity caused by the excessive maximum pressure. ”

“ Since the diesel utilized its heat of combustion more efficiently than the gasoline engine, its cooling fin area could be reduced by 35 percent. This permitted better streamlining. Having less cooling fin area, it warmed up more rapidly than a gasoline engine. ”

“ A wide range of fuels may be used in an internal-combustion engine. They may be either gaseous, liquid, or even solid. In stationary engines hydrogen, coal gas, natural gas, blast-furnace gas, and [156] producer gas are employed to advantage. Volatile fuels, such as alcohol, bensol, gasoline, and kerosene, are turned into a mist or vapor and then burned as a gas. In engines of the Diesel type any liquid fuel ranging down to thick crude oils may be employed, and in one type of engine, which, however, has not proved commercially practicable, coal dust is burned in the cylinder. ”

“ The company is now building cylinders giving outputs of from 1,200 to 1,500 brake horse-power per cylinder, giving outputs of from 5,000 to 6,000 horse-power in tandem twin type engines. As will be seen from the cut, the horizontal Diesel engine is remarkably free from complicated valve gear. ”

“ There have been oil-engines, so called, for many years, but they were really gas-engines since the oil was first heated till it turned into vapour and then that vapour was used as a gas. The Diesel engine, however, actually burns oil in its liquid state. ”

“ The Diesel engine has caused a great deal of comment of late years because of the spectacular uses to which it has been successfully applied. A specially constructed Diesel engine was probably the chief aid in the accomplishment of the first submarine trans-Atlantic voyage by the German submarine “Deutschland.” ”

“ THE DIESEL OIL ENGINE, on account of some features peculiar to it, is treated separately. In 1901 an expert wrote of it that "the engine has not attained any commercial position." Herr Rudolph Diesel, the inventor, has, however, won a high place for his prime-mover among those which consume liquid fuel, on account of its extraordinary economy. ”

“ Thus the Diesel type of engine can be run in any weather on any grade of oil fuel, and as the carburetor and electrical ignition system are absolutely eliminated, two of the great sources of trouble of the automobile163 motor are absent—and this feature, alone, even more than the superior economy of operation, will appeal to the average motorist. ”

“ The Packard diesel failed because it was not a good engine. It was an ingenious engine, and two of the several features it pioneered (the use of magnesium and of a dynamically balanced crankshaft) survive in modern reciprocating engine designs. In addition, when it was first introduced, no other engine could match it for economical fuel consumption and fuel safety. ”

“ No other has such bearing upon precisely those qualities of aerodynamic efficiency, fuel economy, and reliability of airplane and powerplant that most affect commercial usefulness. It is more than three years since the duration record left American shores, and it has been more than doubled in that time. Its return is very welcome.
It is doubly welcome for being made with a fundamentally new type of engine. The diesel principle is not a commercial monopoly. It is open to anyone. ”